Product ID:DK II, 1940
MSDS Date:10/08/1997
FSC:9150
NIIN:00N085358
MSDS Number: CHBMK

RAMCO SPECIALTY PRODUCTS

1400 S SUNKIST NUMBER 91
ANAHEIM, CA 92806-5619
US

Emergency Phone: 800-255-3924

Info Phone: 800-334-7071

Preparer: LINDA SUE SHEPHERD

Cage: 0AV13

RAMCO SPECIALTY PRODUCTS

ANAHEIM, CA 92806-5617 US

Telephone: 714-758-7795/800-334-7071

Cage: 0ZUM2

SEVERELY HYDROTREATED PETROLEUM HYDROCARBON BASE STOCK;

CAS: 64742-58-1

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: N/K

KEROSENE (PETROLEUM), HYDROTREATED; (ALIPHATIC PETROLEUM

CAS: 64742-47-8

RTECS: OA5504000

OSHA PEL 400 PPM (MFR)

ACGIH TLV: N/K

XYLENE (SARA 313) (CERCLA)

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NITRIC ACID, 2-ETHYLHEXYL ESTER; (OCTYLNITRATE)

CAS: 27247-96-7

RTECS: QU7925000

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE IRRITATION.
INGESTION:CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING
AND DIARRHEA. INHALATION:EXCESSIVE INHALATION OF VAPORS CAN CAUSE
NASAL AND RESPIRATORY IRRITATION, CENTRAL NERVOUS SYSTEM EFFECTS
INCLUDING DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, POSSIBLE
UNCON, OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EVEN DEATH. SKIN:PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
OVEREXPOSURE TO THIS MATERIAL, (OR ITS COMPONENTS) HAS APPARENTLY
BEEN FOUND TO CAUSE KIDN EY DAMAGE IN LABORATORY ANIMALS.
Medical Cond Aggravated by Exposure:NONE KNOWN.

First Aid:EYES:FLUSH W/WATER USING EYECUP/FOUNTAIN FOR AT LEAST 15
MINUTES LIFTING UPPER & LOWER LIDS. SEEK MEDICAL ATTENTION.
INGESTION:DO NOT INDUCE VOMITING. KEEP PERSON WARM & QUIET. SEEK
IMMEDIATE MEDICAL ATTENTION. ASPIRATION OF MATERIAL INTO LUNGS CAN
CAUSE CHEMICAL PNEUM, WHICH CAN BE FATAL. INHAL:REMOVE TO FRESH
AIR. IF BRTHG IS DFCLT, ADMIN OXYG. IF BRTHG HAS STOPPED, ADMIN
ARTF RESP. KEEP PERS WA RM & QUIET. SEEK IMMED MED ATTN. SKIN:
REMOVE CONTAM CLTHG. WASH W/SOAP & WATER FOR AT LST 15 MINS. SEEK
MED ATTN. PROT CLTHG SHOULD BE WORN TO PVNT SKIN CONT. NOTE:
COMPLETE FORMULA AVAILABLE TO MD I N THE EVENT OF A MEDICAL
EMERGENCY.

Flash Point Method:COC
Flash Point:150F,66C
Lower Limits:SEE ING 2
Upper Limits:SEE ING 2
Extinguishing Media:DRY CHEMICAL, CO*2, FOAM. DO NOT USE WATER.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . EVACUATE AREA DOWNWIND.
Unusual Fire/Explosion Hazard:TOXIC FUMES MAY EVOLVE ON
BURNING/EXPOSURE TO HEAT. COULD BE EXPLOSIVE IN CONFINED SPACES IF
EXPOSED TO SOURCE OF IGNITION. NEVER USE WELDING/CUTTING TORCH
ON/NEAR DRUM, (EVEN EMPTY) BECAUSE PRODUCT, (EVEN JUST RESIDUE)
CAN IGNITE EXPLOSIVELY.

Spill Release Procedures:STOP SPILL AT SOURCE. ELIMINATE ALL SOURCES OF
IGNITION. PUMP EXCESS LIQUID TO APPROPRIATE STORAGE CONTAINER.
ABSORB SMALL SPILLS W/ABSORBENT MATERIAL. PERSONS NOT WEARING
PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE NEAR OPEN FLAME OR OTHER
SOURCES OF IGNITION.
Other Precautions:COMBUSTIBLE LIQUID. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE NORMALLY REQUIRED.
Ventilation:SUFFICIENT TO MAINTAIN ATMOSPHERE BELOW TLV LIMIT.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES AND FULL LENGTH
FACESHIELD .
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . CHEMICALLY RESISTANT BOOTS & APRON RECOMMENDED.
Work Hygienic Practices:WASH HANDS W/SOAP & WATER BEFORE EATING,
DRINKING/SMOKING. WASH/SHOWER IF GENERAL CONTACT OCCURS. REMOVE &
LAUNDER OIL SOAKED CLOTHING BEFORE REUSE. DISCARD CONTAMINATED
LEATHER GLOVES & SHOES.
Supplemental Safety and Health

Boiling Pt:B.P. Text:>350F,>177C
Vapor Density:>5
Spec Gravity:0.869 (H*2O=1)
Evaporation Rate & Reference:<0.1 (N-BUTYL ACETATE=1)
Appearance and Odor:CLEAR AMBER LIQUID; MILD PETROLEUM ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, HYPOCHLORITES, CHLORINE.
Stability Condition to Avoid:DO NOT HEAT ABOVE FLASH POINT.
Hazardous Decomposition Products:MAY CAUSE TOXIC MATERIALS: CARBON
DIOXIDE, CARBON MONOXIDE, VARIOUS HYDROCARBONS, OXIDES OF NITROGEN,
ETC.

Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.